Product ID:ENRICH GLOSS POLYURETHANE VARNISH, 090
MSDS Date:07/25/1990
FSC:8040
NIIN:00N073267
MSDS Number: CBZWY

TRU-TEST MFG CO

201 JANDUS RD
CARY, IL 60013
US

Emergency Phone: 800-228-5635

Info Phone: 708-639-5383

Cage: 3D277

TRU-TEST MFG CO

CARY, IL 60013 US

Telephone: 708-639-5383

Cage: 3D277

KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS) VP

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: 48-53%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

<450 G/L

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SEVERE EYE IRRITATION, DRYING OF SKIN.
EXCESSIVE INHALATION CAUSES HEADACHE, DIZZINESS AND NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO MANUFACTURER.

First Aid:EYES: WASH WITH FRESH WATER FOR AT LEAST 15 MINUTES. SKIN:
WASH SKIN WITH WARM WATER AND SOAP. INHALATION: REMOVE TO FRESH
AIR. APPLY ARTIFICIAL RESPIRATION IF NECESSARY. GET MEDICAL
ATTENTION. INGEST ION: DO NOT INDUCE VOMITING. KEEP PERSON WARM AND
QUIET. GET MEDICAL ATTENTION.

Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
TREAT AS A VOLATILE LIQUID FIRE. WATER SPRAY MAY BE INEFTIVE. IF
WATER SPRAY IS USED, FOG NOZZS ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, SPARKS AND OPEN FLAME.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL,
ABSORB LIQUID WITH CLAY, SAND OR FLOOR ABSORBENT. PREVENT RUN-OFF
TO SEWERS, STREAMS OR OTHER BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAMES. FOR STORAGE CONDITIONS SEE OSHA 1910.106.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT WITH
SKIN. CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL
OF MORE THAN 2-3 INCHES WHEN POURING.

Respiratory Protection:NIOSH APPROVED AIR SUPPLIED RESPIRATOR IF TLV
LIMITS ARE EXCEEDED. NIOSH APPROVED MECHANICAL FILTER TO REMOVE
SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING APPLICATION.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLTHNG & BOOTS ARE SUGGESTED TO PREVENT PRLNGD/RPTD SKIN
CNTCT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
BATHROOM. DO NOT REUSE CONTAMINATED CLOTHING.
Supplemental Safety and Health
EYE PROT: & FULL LENGTH FACESHIELD .

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.9105
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:58

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ISOLATE FROM HEAT AND OPEN FIRE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.